Job Responsibilities:
Work closely with operation Manager to review, evaluate and operate the electrical system including:- To provide advice to management on the compliance to the Electricity Supply Act 447 and Electricity Regulation 1994. Responsible to sign off Permit to Work for electrical projects and maintenance while ensuring all safety standards are complied. Perform new production tool buy off to ensure compliance to the act. To audit electrical installations to ensure compliance. To work closely with the electrical engineer on project design and commissioning. Guide Chargeman of the site to maintain electrical equipment. Connect between owner and energy commission in any mode of communications including the submission of weekly Form I to Energy Commission. Advice and assist in the establishment of the Emergency Response Plan and Emergency Remedial and Recovery Action Plan.Monitor, review and analyse any alarms, update failure modes and effects analysis (FMEA) & electrical risk assessment. To perform weekly inspection of 132kV installations and submit report to Energy Commission. Liaise with TNB and local authorities related to power supply outage and plan shutdown maintenance, activities pertaining to electrical and HV power distribution system. To attend to power supply interruption and breakdown. Ensure all maintenance and operations programs are properly implemented in order to have optimum and sustainable performances. Ensure no downtime that cause by lack of maintenance or troubleshooting, improper maintenance or troubleshooting procedure or not adequate maintenance frequency for equipment. Ensure smooth operation without interruption or near miss due to negligence in daily operation and maintenance activities. Ensure that scheduled routine taking reading and maintenance work if necessary for HT/LV and genset system are carried out. Monitor defect rectification works by turnkey contractor. Comply predefined schedule and complete all maintenance and operation on time. Arrange and supervise manning for a day to day maintenance and services operation. Optimize maintenance and operation procedures to improve energy saving. Able to manage the maintenance scope (maintenance, repair & operations (MRO) for building M&E, RO water treatment plant, Compressor ((CDA (Clean Dry Air) Systems – Compressors, driers, cooling system, boosters, motors, piping, valves, actuators)), Vacuum Chiller, HVAC Cooling system and Bulk gas system. Able to manage Vacuum Systems – Plant vacuum equipment, distribution system, controls, and monitoring. SCADA and Controls Systems – monitoring and alarm management, trending and reporting for all site systems. Support and monitor sites on emergency situations. Other duties as and when assigned. High & Medium Voltage distribution:- 132kV Switchgear and Breakers 11kV Switchgears and Breakers Transformers Power and distributionsProtection relays Electrical testing & commissioning (TTR, insulation resistance, Power Factor Insulation, Dissolved Gas Analysis, Dielectric Breakdown Voltage, Circuit Breaker Testing, Protective Relay Calibration). Low Voltage systems including ACB, Switchgears, MCC , PFIC , PDB etc.Power System Study (Short Circuit, Coordination, Arc Flash) Power System and Controls single-line diagram interpretation UPS (Uninterruptible Power Supply) and DC chargers system VFD (Variable-speed drives) Earthing and bondingPFIC systemFire detection and Suppression systemHT and LT Motors including their protections and controlHV, MV and LV Power and control cables.Lightening systemLighting and distributions. Job Requirements:
Must be registered as 132kV Competent Electrical Engineer with Energy Commission or Professional Engineers with Practising Certificated (PEPC) of Board of Engineers Malaysia (BEM) or Institute of Engineers Malaysia (IEM). Bachelor's Degree in Electrical Engineering registered with BEM. Minimum 10 years of site supervision experience especially in electrical, engineering projects. Preferred candidate from manufacturing industry. Has at least 5 years of experience in 132kV operations. Strong knowledge of construction methods, materials, and quality standards. Excellent project management and communication skills. Ability to work collaboratively in a team environment. Applicants should be willing to be based in Melaka. Hostel will be provided for successful candidate if required.